Champion Category 5 46538 El manual del propietario

46538 Rev 46538-20100614 www.championpowerequipment.com 10006 Santa Fe Springs Road Santa Fe Springs, CA 90670 USA Made in China 3500 Peak Watts /

Controls and Features 6 Rev 46538-20100614 E Power Panel (1) Ignition Switch (2) Intelligauge – Three mode digital meter for running hours, v

Controls and Features Rev 46538-20100614 E 7 Parts Included Your Model 46538 Gasoline Powered Generator ships with the following parts: Wheel Ki

Assembly 8 Rev 46538-20100614 E Assembly Your generator requires some assembly. This unit ships from our factory without oil. It must be properly s

Assembly Rev 46538-20100614 E 9 Connect the Battery 1. Remove the protective cover from the red battery lead. 2. Attach the red lead to the re

Assembly 10 Rev 46538-20100614 E NOTE The generator rotor has a sealed, pre-lubricated ball bearing that requires no additional lubrication for

Operation Rev 46538-20100614 E 11 Operation Generator Location Please consult your local authority. In some areas, generators must be registered wit

Operation 12 Rev 46538-20100614 E NOTE If the engine starts but does not run make certain that the generator is on a flat, level surface. The en

Operation Rev 46538-20100614 E 13 Power Management Use the following formula to convert voltage and amperage to watts: Volts x Amps = Watts To pro

Maintenance 14 Rev 46538-20100614 E Maintenance The owner/operator is responsible for all periodic maintenance. WARNING Never operate a damaged o

Maintenance Rev 46538-20100614 E 15 Spark Arrester 1. Allow the engine to cool completely before servicing the spark arrester. 2. Remove the two

Storage 16 Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. For longer term storage, pl

Specifications Rev 46538-20100614 E 17 Specifications Engine Specifications Engine 196 cc OHV CPE Electric Start Generator Specifications Runnin

Specifications 18 Rev 46538-20100614 E Parts Diagram

Specifications Rev 46538-20100614 E 19 Parts List Item Part Number Description Qty. 1 ST02FD-04120000-CARB Fuel Meter Assembly 1 2 GB819 M

Specifications 20 Rev 46538-20100614 E Item Part Number Description Qty. 52 GB818 M5X15 Screw M5×15 2 53 ST188FD-1741002-C Handle sheath 1

Specifications Rev 46538-20100614 E 21 Item Part Number Description Qty. 106 ST188FD-1750002-C7 Battery black wire (-) 1 107 ST168FD-1751002

Specifications 22 Rev 46538-20100614 E Wiring Diagram

Troubleshooting Rev 46538-20100614 E 23 Troubleshooting Problem Cause Solution Generator will not start No fuel Add fuel Faulty spark plug R

Warranty 24 Rev 46538-20100614 E Warranty CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Effective September 1, 2006. Replaces all undated warra

Warranty Rev 46538-20100614 E 25 Champion Power Equipment, Inc (CPE), The California Air Resources Board (CARB) and the United States Environment

Table of Contents Introduction ... 1Portable Power Generator ... 1Accessories ...

Warranty 26 Rev 46538-20100614 E EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System W

Warranty Rev 46538-20100614 E 27 engine. Such use voids this ECS Warranty and shall be sufficient grounds for disallowing an ECS Warranty claim. C

Introduction Rev 46538-20100614 E 1 Introduction Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and builds

Manual Conventions 2 Rev 46538-20100614 E Manual Conventions This manual uses the following symbols to help differentiate between different kinds o

Safety Rules Rev 46538-20100614 E 3 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instru

Safety Rules 4 Rev 46538-20100614 E WARNING Operation of This Equipment May Create Sparks That Can Start Fires Around Dry Vegetation. A Spark Ar

Controls and Features Rev 46538-20100614 E 5 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself